歡迎來到上海松夏減震器有限公司空氣彈簧官方網站

空氣彈簧刚度帘线角度非线性性能介绍

作者:admin    来源:未知    发布时间:2019-05-06 14:58    浏览量:
   囊式空氣彈簧刚度帘线角度非线性性能介绍:
   Introduction to the angular nonlinearity of the air spring spring stiffness cord:
囊式空氣彈簧
   1、当空氣彈簧垂直位移时,空氣彈簧的体积变化很大,产生明显的垂直非线性特征;横向位移时,空氣彈簧的体积变化很小,横向特性是线性的。
  1. When the air spring is vertically displaced, the volume of the air spring changes greatly, resulting in obvious vertical nonlinear characteristics;Lateral displacement, the volume of the air spring  change very little, lateral characteristics are linear.
   2、空氣彈簧内压越大,垂直刚度越大,空氣彈簧内压对横向刚度的影响越小。
   2, the greater the internal pressure of the air spring, the greater the vertical stiffness, and the smaller the impact of the internal pressure of the air spring on the lateral stiffness.
    3、帘线角度对垂直刚度和横向刚度有很大影响,对胶囊的强度也有很大影响。工作过程的VS图表明,绳索主要是由于绳索引起的。当角度不同时,当空氣彈簧变形时,体积和有效面积会发生变化,这会导致垂直和横向特性发生变化,这不能通过经验公式反映出来。
   3. Cord Angle has a great influence on vertical stiffness and transverse stiffness, as well as on the strength of the capsule.The VS diagram of the working process shows that the rope is mainly caused by the rope.When the Angle is different, when the air spring is deformed, the volume and effective area will change, which will lead to a change in the vertical and horizontal characteristics, which cannot be reflected by the empirical formula.
囊式空氣彈簧的性能介绍
   4、簾線密度和層間距離對膠囊的縱向剛度和橫向剛度影響不大,但對膠囊的強度影響較大。隨著臍帶密度的增加,各層間的距離逐漸增大。有效地降低了簾線層的最大應力。
   4. Curtain line density and the distance between layers have little influence on the longitudinal stiffness and transverse stiffness of the capsule, but have a great influence on the strength of the capsule.As umbilical cord density increased, the distance between layers gradually increased.The maximum stress of the cord layer is effectively reduced.
   5、簾線層數對垂向剛度影響不大,但對橫向剛度影響較大。增加簾線層數可以獲得較大的橫向剛度,並能有效降低簾線層數的最大應力。
   5. The number of cord layers has little influence on vertical stiffness, but great influence on transverse stiffness.Increasing the number of cord layers can obtain greater lateral stiffness and effectively reduce the maximum stress of cord layers.
双球的空氣彈簧
 

相關在线视频推薦

關注官方微信

Copyright © 2015-2025 在线视频 在线视频 網站地圖 站點地圖